院报 ›› 2023, Vol. 40 ›› Issue (10): 108-114.DOI: 10.11988/ckyyb.20220620

• 岩土工程 • 上一篇    下一篇

膨胀土裂缝灌浆效果可视化定量评价方法

周学友1, 张敏1, 常兆广1, 翟晓平1, 丁浩桢2,3, 王新志2,3   

  1. 1.中国南水北调集团中线有限公司渠首分公司,河南 南阳 473000;
    2.中国科学院武汉岩土力学研究所 岩土力学与工程国家重点实验室,武汉 430071;
    3.中国科学院大学,北京 100049
  • 收稿日期:2022-06-02 修回日期:2022-09-26 出版日期:2023-10-01 发布日期:2023-10-13
  • 通讯作者: 丁浩桢(1998-),男,河南信阳人,博士研究生,主要从事海洋岛礁岩土工程工作。E-mail: dinghaozhen20@mails.ucas.ac.cn
  • 作者简介:周学友(1981-),男,青海乐都人,高级工程师,主要从事水利工程建设运行管理工作。E-mail: 9710916@qq.com
  • 基金资助:
    国家自然科学基金项目(41572297)

A Visual Quantitative Method for Evaluating the Effectiveness of Grouting Expansive Soil Cracks

ZHOU Xue-you1, ZHANG Min1, CHANG Zhao-guang1, ZHAI Xiao-ping1, DING Hao-zhen2,3, WANG Xin-zhi2,3   

  1. 1. Head Section Branch, Middle Route of China South-to-North Water Diversion Co., Ltd., Nanyang 473000, China;
    2. State Key Laboratory of Geomechanics and Geotechnical Engineering, Institute of Rock and Soil Mechanics, Chinese Academy of Sciences, Wuhan 430071, China;
    3. University of Chinese Academy of Sciences, Beijing 100049, China
  • Received:2022-06-02 Revised:2022-09-26 Online:2023-10-01 Published:2023-10-13

PDF

333

摘要： 膨胀土裂缝灌浆效果评价是工程界的一大难题。采用微米CT扫描对膨胀土试样裂缝的灌浆充填效果进行了定量评价和分析,提出采用整体孔隙率、逐层面孔隙率、孔隙等效直径与灌入指数等指标对膨胀土裂缝灌浆充填效果进行定量综合分析。采用超细水泥和膨胀土配置4种浆液对膨胀土裂缝进行灌浆试验,在灌浆前、后对试样进行CT扫描获取内部切片图像后再进行三维重建和后处理分析。采用整体孔隙率、逐层面孔隙率、孔隙等效直径和灌入指数定量分析了膨胀土裂缝灌浆效果和最小可灌入裂缝宽度。结果表明:浆液的可灌性随水固比增大而提高;灌入水固比为1.2的浆液可使膨胀土试样的整体孔隙率降低幅度可达到99%以上,其中超细水泥含量50%的浆液可灌入的最小裂缝宽度为0.6 mm。该方法可为定量评估各类浆液在膨胀土裂缝中的灌浆充填效果提供参考。

关键词: 膨胀土, CT扫描, 孔隙率, 灌浆材料, 裂缝

Abstract: Assessing the effectiveness of grouting expansive soil cracks presents a formidable challenge in the field of engineering. In this study, we employed micro-CT scanning technology to quantitatively evaluate the grout filling effect of cracks within expansive soil specimens. Slurries of ultra-fine cement and expansive soil with varied dosage was utilized to grout the cracks. CT scans were conducted before and after grouting to obtain internal slice images, which were then subjected to three-dimensional reconstruction and post-processing analysis. The grouting effect of expansive soil cracks and the minimum width of groutable cracks were quantitatively analyzed using overall porosity, layer-by-layer porosity, pore equivalent diameter, and groutable index. The results illustrated that the groutability of slurry improves with an increase in the water-solid ratio. A water-solid ratio of 1.2 can reduce the overall porosity of expansive soil samples by over 99%, and the minimum crack width for a slurry with an ultra-fine cement content of 50% is 0.6 mm. This method provides a reference for quantitatively evaluating the grouting and filling effects of various slurries in expansive soil cracks.

Key words: expansive soil, CT scan, porosity, grouting materials, crack

中图分类号: 

*严禁使用本系统存储、处理、传输涉密信息*
本系统由北京玛格泰克科技发展有限公司设计开发 技术支持：support@magtech.com.cn
Baidu
map